DOI: 10.1016/J.CSCM.2017.06.004 Corpus ID: 135244688; Stress-strain characteristics of concrete containing quarry rock dust as partial replacement of sand @article{Kankam2017StressstrainCO, title={Stress-strain characteristics of concrete containing quarry rock dust as partial replacement of sand}, author={Charles K. …

This is part of a research on the structural characteristics of concrete using lateritic sand and quarry dust as fine aggregate. This paper presents the results of an experimental study ...

Workability, compressive strength tests were conducted on basic three quarry dust concrete grade mixes which vary quarry dust ratio percentage from 0.41 to 0.43 according to the British design ...

Concrete mechanical properties could be improved through adding different materials at the mixing stage. Quarry dust (QD) is the waste produced by manufactured sand machines and comprise ...

The Strength Characteristics of Concrete Blended with Recycled Concrete, Quarry Dust and ... Type E– cement, quarry dust, 50% glass, 50% recycled concrete aggregates. ...

The study has conducted to determine the workability and compressive strength of the self –compacting concrete. The sand has replaced with quarry dust with the proportion of 10, 20, 30 and 40% ...

Attempts have been made to study the properties of concrete and to investigate some properties of quarry dust reinforced with steel fibers; this article presents the compressive and split tensile ...

Quarry dust The basic tests on quarry dust were conducted as per IS-383-1987 and its specific gravity was around 1.95. Wet sieving of quarry dust through a 90 micron sieve was found to be 78% and the corresponding bulking value of quarry dust was 34.13%. Coarse aggregate replacement of sand with quarry dust of mortar cube (C

concrete exhibited relatively poor characteristics at early ages, but it achieved similar strength and transport characteristics to silica fume concrete in the long term

The grading properties and the fines content of quarry dust may have contributed to the characteristics of stress-strain curve of concrete with quarry dust. …

The primary goals of this paper are to create SCC mixes with quarry dust that satisfy the standards for workability and compare the compressive strength of the created SCC to the control mix. Self-compacted concrete was designed in three different mixes, Mix-A, Mix-B, and Mix-C, and the outcomes were compared to the Control Mix.

Quarry stone dust concrete generally showed average of 27% increase in compressive strength higher than the river sand concrete. It was also observed that concrete mix with 50% quarry stone dust ...

The mix quantity for 1m3 concrete was 315 kg Class F fly ash, 315 kg OPC, 630 kg quarry dust, 508 kg river sand, 400 kg coarse aggregate, 0.7% superplasticizer,0.32 % w/b, 0.10% macro fiber ...

Concrete mechanical properties could be improved through adding different materials at the mixing stage. Quarry dust (QD) is the waste produced by manufactured sand machines and comprise …

According to Kapgate et al. (2013), the presence of a higher content of fines in the quarry dust contributed to enhanced strength qualities by improving the cohesiveness of the concrete.

The strength and durability characteristics of concrete with quarry rock dust as fine aggregate were investigated by Langovan et al. (2008). The viability of employing marble sludge powder and quarry dust as a complete replacement for sand was investigated by Shahul Hameed and Sekar.

The Strength Characteristics of Concrete Blended with Recycled Concrete, Quarry Dust and Broken Glass August 2022 Journal of Engineering Research and Reports 23(1):10 - 21

In such a situation the Quarry dust can be an economic alternative to the river sand. The study analyses the effect on strength characteristics by various % of quarry dust as a replacement of natural sand in M40 grade concrete and also the combination of various % of quarry dust and Fly ash as a replacement of natural sand

The use of quarry dust in concrete according to Chaturanga et al., [25] is desirable because of the benefits such as useful disposal of a by-product, reduction of river sand consumption and increase in strength. Quarry dust has rough, sharp and angular particles, and as such causes a gain in strength due to better interlocking.

To decrease the environmental impact of processing quarry dust and E-Waste for ... The practical examination has been carried out in order to determine the strength characteristics of concrete ...

The mechanical and durability characteristics of the concrete using the three mixtures were analyzed. It has been observed that the mechanical and durability characteristics of a concrete mixture incorporating a fly ash-15%, aluminum dross-10%, and quarry dust-20% are better than that of standard concrete.

Several studies have shown that quarry waste can be used as a substitute for fine aggregate in concrete without compromising the strength of the finished product across a variety of concrete ...

Mix design has been developed for three grades using design an approach IS, ACI, USBR, RN.No.4 and BRITISH for both conventional concrete and quarry dust concrete. Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust and the results were compared with the Natural Sand Concrete.

DOI: 10.1155/2016/1742769 Corpus ID: 55828666; Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete @article{Prakash2016StudyOC, title={Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete}, author={K. Shyam Prakash and Ch. Hanumantha Rao}, journal={Advances in Civil Engineering}, …

1. Introduction. Light weight concrete is low density a concrete and the values in par with the conventional concrete. Its density varies from 900- 1900 kg/m 3 with reference to its compressive strength. It has good properties such as easy handling, preparing and cheaper, and hence this type of concrete popularizing in construction field.

On the other hand, stone dust, a waste from the quarrying industry, offers a cost-effective and practical solution for producing concrete. This article presents a …

The strength characteristics of the specimens decreased with increasing percentage replacements of quarry dust in comparison with conventional concrete. …

This research was conducted to examine the potential of basaltic crusher dust as a partial replacement for Portland Pozzolana cement in hollow concrete block (HCB) production. Quarry dust is one of the waste materials abundantly available and pozzolanic material in the quarry industry. In doing so, physical tests of cement pastes …

It was observed that the increase in the quarry dust content from 0% to 75% by the total mass of fine aggregate, there was a corresponding decrease in the …